There is a lack of information related to adapting high tunnel systems to humid, subtropical climates in the Southeastern United States, resulting in a disadvantage for their use to extend growing seasons and meet the increasing demand for local horticulture products. This research project explored the possibility of growing organic broccoli and cauliflower (Brassica oleracea L.) under high tunnels during two consecutive fall/winter seasons in northeast Georgia (USDA plant hardiness zone 8a), particularly evaluating questions related to crop feasibility, planting dates and cultivar choices. Marketable yields for high tunnel broccoli ranged from ≈11,800 to 15,800 kg·ha−1 and were not consistently affected by either planting date or cultivar type. Broccoli required an additional 8–45 days to reach maturity compared with seed catalog estimates with harvesting occurring during mid-December to mid-January. Marketable yields for high tunnel cauliflower ranged from ≈8600 to 26,000 kg·ha−1 and were affected primarily by the cultivar type. Cauliflower required an additional 19–56 days to mature with harvesting occurring during the entire month of January. The first season was cooler than the second with the lowest growing degree days (GDD) units accumulated during the months of January and February. Differences in air temperature at the crop canopy between the high tunnel system and open field were largely related to high tunnel ventilation protocols that changed as the season progressed. An average heat gain of 7 to 8 °C under the high tunnels at crop canopy height was documented on the coldest days and an average of 1 °C gain on the warmest days compared with the open field. Overall, winter broccoli appeared more adaptable to high tunnels than cauliflower but production of both crops may be possible if planting dates and cultivar types are taken into account for the region.
High tunnels are plastic-covered, greenhouses where crops are typically grown in the soil and the temperature is passively managed (e.g., ventilation, shadecloth, heat sinks, insulation, etc.) (Wells and Loy, 1993; Wittwer and Castilla, 1995). The popularity of high tunnels has been growing steadily in the United States (Carey et al., 2009; Hochmuth and Toro, 2014). Using high tunnels allows farmers to reduce weather-related risks; improve product quality and consistency; assist with organic growing efforts; and be productive on limited amounts of land, amplify season extension opportunities, or both (Carey et al., 2009; Lamont, 2009; O’Connell et al., 2012). Since 2010, competitive cost-share programs administered by the Natural Resource Conservation Service have provided an additional incentive for growers to invest and explore the benefits of these protected environment systems.
There is a lack of information related to adapting high tunnels to humid, subtropical climates in the southeastern United States including parts of Alabama (AL), Arkansas (AR), Florida (FL), Georgia (GA), Louisiana (LA), Mississippi (MS), North Carolina (NC), South Carolina (SC), Texas (TX), and Virginia (VA) according to the Koppen climate classification system. Currently, the Southeast is at a disadvantage for using high tunnels optimally compared with cooler and less humid areas where a greater body of knowledge exists. Key areas needing additional research include structure design, crop selection, planting dates, cultivar choice, crop rotation strategies, pest and disease management and other cultural practices.
The state of GA, similar to many locations in the Southeast, is subject to short, mild winters interrupted by cold snaps (NCEI, 1982). The average daily winter temperatures range from 4 to 13 °C which is reflected by USDA hardiness zones 6a to 9a (USDA, 2012a). The number of nights subject to freeze warnings has a wide range (e.g., 10 to 110 nights) depending on latitude and elevation. From mid-November to mid-March, the hours of daylight range from ≈10 to 12 h with a daily light integral (DLI) ranging from 15 to 35 mol·m−2·d−1 (Korcyznski et al., 2002; USNO, 2015). There is a lack of information about the minimum average DLI required for many fruit or vegetable crops but the predicted temperatures indicate that many opportunities to grow and/or hold crops under high tunnels in the Southeast during the fall/winter season is possible. This is different from, for example in Maine, where less than 38% of high tunnel growers plant winter crops (Fitzgerald and Hutton, 2012). Typical high tunnel crops grown in the Southeast during the fall/winter season include salad and cooking greens, root crops, alliums, and overwintered flowers. It is unclear, if these choices reflect information from cooler or more light-limited regions which have influenced high tunnel grower crop choices or if they are related to profitability (i.e., customer demand, quick turnover, etc.).
The following studies have evaluated high tunnel use for fruit and vegetable production in the humid, subtropical areas documenting benefits and challenges associated with their use. A strawberry study conducted in FL found 54% greater yields and marketable fruit weight 69% greater under high tunnels compared with open field production (Salame-Donoso et al., 2010). In NC, differences among strawberry cultivars correlated with greater yields under high tunnels indicating the importance of crop and cultivar selection (Gu et al., 2017). An organic tomato study in NC found that heirlooms grown under high tunnels in the spring and summer had equal or greater yields depending on the year, and they were consistently harvested three weeks earlier than the field (O’Connell et al., 2012). In GA, organic spring lettuce yields were equal or greater for a high tunnel system compared with the field depending on the year and were 2–7 d earlier (Jayalath, 2016). An early spring lettuce crop in TN achieved not only greater total yields under high tunnels compared with the field but the crop was also subject to more pest, disease, and physiological damage, reducing marketability of the crop (Wallace et al., 2012). Two studies (GA and NC) found that early blooming of small fruits (i.e., strawberry and Southern highbush blueberry) under high tunnels may increase frost damage and fruit abortion because of early bloom times (Gu et al., 2017; Ogden and van Iersel, 2009). Overall, high tunnels appear to offer a benefit in the region but yearly weather conditions, structure/system characteristics, cultivar selection, and crop sensitivity to fluctuating temperatures may affect potential yield gains.
Informally interviewed high tunnel growers, in the same climate and hardiness zone as our research project, indicated that they would be interested in integrating other crops into their fall/winter portfolio. This would help meet growing year-round and winter holiday market demand for local and organic produce and help expand crop rotation options (Celia Barss, Nicholas Donck and Jay Payne, personal communication, Summer 2015). The National Farmers Market Directory also reports the rapid growth of winter markets (USDA, 2012b).
Open-field broccoli and cauliflower are generally planted in the late summer or early fall and harvested during the months of October and November in this area. The optimal temperatures for crop growth are 15 to 18 °C while avoiding temperatures ≥30 °C (Heather et al., 1992; Maynard and Hochmuth, 2007). These temperature ranges indicate that growing broccoli and cauliflower during late fall and early winter under high tunnels would be possible although it is not typical. This schedule could lead to season extension opportunities from November through January. Therefore, this research project explored the possibility of growing atypical broccoli and cauliflower (Brassica oleracea L.) crops under high tunnels during the fall/winter season in northeast GA (Zone 8a). Specific objectives were to evaluate crop feasibility, planting dates, and cultivar choices.
Materials and Methods
A replicated comparison of multiple broccoli and cauliflower cultivars transplanted at two different fall planting dates and managed with certified organic practices under high tunnels was carried out over two growing seasons. Differences in crop yields and days to harvest after transplanting were evaluated while pest and disease issues were monitored. In addition, microenvironmental parameters inside and outside the high tunnels were compared.
The study was conducted at the University of Georgia, Durham Horticulture Research Farm located in Watkinsville, GA (lat. 33.88689 N, long. 83.41941 W) from 2014 to 2016. Soils at this site are categorized as a well-drained Cecil sandy loam soil that has been eroded overtime so that the plow layer now extends into the red sandy clay loam subsoil (CYB2) (NRCS-USDA, 1968). The project site has been certified organic since 2012, and all production methods were performed under the guidelines of the USDA National Organic Program certification standards (7 U.S.C. §6501). There was no recent history of Brassicaceae crops in the project area before our study. Between the two brassica-growing seasons, a spring organic lettuce (Lactuca sativa) crop followed by a pearl millet (Pennisetum glaucum) cover crop was planted under both high tunnels. The pearl millet cover crop was mowed and incorporated into the soil using a tractor-mounted rotary tiller 1 month before transplanting the brassica crops.
Two snow-arch design high tunnels (29.3 × 9.1 × 3.7 m) were used for the experiment (Atlas Greenhouses Inc., Alapaha, GA). High tunnel features included bows every 1.8 m, an inflated double polyethylene film roof (0.15 mm thickness) (SunView4; Poly-Ag Corp., San Diego, CA), twin-wall polycarbonate end walls, and an automated “1.8 m Z-Lock drop-down curtain system” fabric side curtains (0.3 mm thickness). The high tunnels were oriented east–west to minimize high tunnel surface area exposed to the prevailing westerly winter winds.
The experiment was a split-plot design and treatments were replicated four times (i.e., two blocks in each commercial-size high tunnel). The main plot was planting date and the subplot treatment was cultivar. In 2014, planting dates for both crops were 7 Oct. and 21 Oct. In 2015, planting dates were 22 Sept. and 6 Oct., 2 weeks earlier than the first season. Dates were modified in the second season to achieve a greater overlap of the harvest period during the months of November to January.
Four broccoli (Brassica oleracea var. italica) cultivars were evaluated: ‘Belstar’ and ‘Fiesta’ (High Mowing Seeds, Wolcott, VT), ‘Imperial’ and ‘Marathon’ (Johnny’s Selected Seeds, Winslow, ME) and three cauliflower (Brassica oleracea var. botrytis) cultivars were evaluated including ‘Amazing’, ‘Denali’ (Johnny’s Selected Seeds), and ‘Snowball Y’(High Mowing Seeds). Cultivar choices were based on seed catalog descriptions promoting appropriateness for fall season production and similar days to harvest (≈65–75 d).
Crop management and data collection were carried out by block. Both crops were grown in 0.9 m wide raised beds with an east–west orientation. Each broccoli block consisted of one 3.4-m long row with 30.5 cm in-row spacing for a total of 11 plants per experimental unit. Each cauliflower block consisted of one 4.6-m long row with 45.7 cm in-row spacing for a total of nine plants per experimental unit. Footpaths in between rows were 30.5 cm wide. If extrapolated to 1 ha for each crop, there was a planting density of 25,000 broccoli plants/ha (0.28 m2/plant) and 16,667 cauliflower plants/ha (0.42 m2/plant). This assumes that ≈70% of the available area was planted with crops and 30% devoted to foot paths, work spaces, etc. under the high tunnels. Blocks were re-randomized each year and guard rows were included on lateral sides of each high tunnel to minimize edge effects from sun, wind, etc.
Transplants were grown onsite in a heated greenhouse maintained at 13 to 20 °C night-time/day-time temperatures. Seeds were sown into 36-cell packs (L-606; Landmark Plastic Corp., Akron, OH) filled with potting soil (Sunshine Natural & Organic Mix #1; Sun Gro Horticulture, Agawam, MA). Overhead irrigation was administered by hand as needed. A soluble fish and seaweed fertilizer (AgGrand Organic Series (4N–1.3P–2.5K); Amsoil, Inc., Superior, WI) was applied once per week during the third and fourth week after seeding at a rate of 8 mL·L−1 of water. Seedlings were acclimated to the outside environment 1 week before transplanting to the high tunnels. Seedlings were transplanted when they were 4 weeks old.
Black polypropylene landscape fabric (109 g·m−2), secured with metal fabric pins was used as a weed barrier and heat sink. Holes were cut into the fabric to accommodate the broccoli and cauliflower transplants. Irrigation was administered for ≈60–90 min per cycle every 2–4 d, depending on the growth stage of plants and weather conditions. There was one drip tape with emitters every 20 cm and a flow rate of 1.3 lpm per 31 m per planted row (Chapin Tape; JainUSA, Watertown, NY).
During the growing season, sidewall curtain and end walls were opened and closed with consideration of the air temperature, precipitation, and wind speed. Dropdown sidewall curtains were lowered (i.e., opened) when ambient air temperatures inside the tunnels at 1.8 m above the soil line exceeded 15.6 ± 1 °C. The side curtain threshold temperature was chosen based on the optimum growth temperatures for brassica crops (15 to 18 °C). When rain or strong winds (>24 kph) occurred the side and/or end walls were closed as long as the high tunnel temperature was not predicted to surpass 26 °C. This protocol was necessary to keep roof/sidewall runoff from flooding the high tunnel soil, rain blowing into the tunnels, andstrong winds from damaging the plants or side wall curtains.
One layer of intermediate weight rowcover (i.e., 41 g·m−2) (‘Gro-Guard #40’; Atmore Industries, Atmore, AL) was hung over wire hoops to create a low tunnel over the plants when the nighttime temperatures were predicted to be ≤0 °C. The low tunnel apex was ≈1 m above the soil line. Row cover edges were held in place with weighted sand bags. Placement of rowcovers were carried out during the late afternoon (4:00 to 6:00 pm) and removed the following morning (8:00 to 9:00 am).
Pest management decisions were based on observations from biweekly scouting and treatment actions were based on established integrated pest management (IPM) thresholds for organic systems when available. The following products were used to manage pest and disease pressure: insecticidal soap for aphids (Brevicoryne brassicae and Macrosiphum euphorbia) (M-Pede; Dow AgroSciences, Indianapolis, IN), neem oil combined with insecticidal soap for whiteflies (Neem Concentrate; Green Light; San Antonio, TX), Bacillus thurigiensis for cabbage loopers (Trichoplusia ni) and cabbage worms (Artogeia rapae) (Dipel DF; Valent BioSciences Corp., Libertyville, IL), spinosad for fire ants (Entrust SC Naturalyte; Dow AgroSciences) copper hydroxide for gray mold (Botryis cinera) and downy mildew (Hyaloperonospora parasitica) (NuCop 50WP; Albaugh, Inc., Ankeny, IA), and snap traps for mice.
Soil amendment and fertilizer inputs.
Fertilizer applications were the same for the broccoli and cauliflower crops. Preplant soil amendments and fertilizers used included compost, feathermeal, rock phosphate, potassium sulfate, boron, and lime (Table 1). Compost, lime (2014–15 only), nitrogen, and boron applications were consistent across all blocks. Phosphorus and potassium applications were different among blocks to bring them up to comparable levels; the differences among blocks were likely due to slight differences in soil texture (sandy loam to sandy clay loam) and percent organic matter (3% to 5%). These differences may have been inherent or a result of high tunnel site preparation activities conducted in 2014 (i.e., grading soil to create level ground). Fertilizers were applied by block and shallowly incorporated.
Soil amendments and fertilizer inputs for brassica crops.
Rates were based on using the low range of soil test recommendations from the UGA Agriculture and Environmental Services Laboratory (AESL) (Athens, GA). In 2014, the preplant fertilizer N rate was 157 kg·ha−1. About 6 weeks after planting, crops were side-dressed with an additional 45 kg N/ha (Table 1). Plant tissue analysis conducted at the pre-heading stage for both broccoli and cauliflower indicated that the N concentrations were greater (≈8% to 9%) than the recommended range (≈6%). Therefore, in 2015, the pre-plant fertilizer N rate was decreased by ≈15% to 135 kg N/ha. In 2015, follow-up plant tissue analysis conducted at the preheading stage indicated that the N concentrations were lower than the previous year (≈7%) but still 1% to 2% greater than the recommended range. The rate and timing of the side-dress fertilizer application was kept the same both years (Table 1).
Both broccoli and cauliflower were harvested twice per week. Broccoli was harvested twice per week between 30 Dec. 2014 to 16 Feb. in 2015 and 1 Dec. 2015 to 8 Jan. 2016. Cauliflower was harvested twice per week between 30 Dec. 2014 to 16 Feb. 2015 and 15 Dec. 2015 to 16 Feb. 2016. One head per plant was harvested when it appeared to reach a maximum size (≈13–20 cm) while maintaining good quality according to the USDA maturity standards for bunched broccoli [7 Code of Federal Regulations (CFR) §51.3555] and U.S. No. 1 cauliflower (7 CFR §51.540). Broccoli stalks were trimmed to 15 cm and cauliflower were closely trimmed to ≤1 cm. Heads were sorted into marketable and non-marketable categories. Non-marketable categories for broccoli included insect damage, rodent damage, over-maturity (i.e., loose or flowering buds), and other. Non-marketable categories for cauliflower included the same as broccoli except the over-maturity category included curd separation, riciness, or purpling. The number of individual heads as well as the total weight for each category was recorded.
A variety of microenvironment measurements were recorded with automatic data loggers located within each high tunnel block (i.e., four stations) and an adjacent field area (i.e., four additional stations). All eight microenvironmental monitoring stations measured air temperature, soil temperature, and relative humidity. In 2014–15, HOBO Microstation data loggers were used (#H21-002 with #S-THA-M002, #S-TMB-M002 sensors; Onset Computer Corp., Bourne, MA); during the 2015–16 season, Decagon Devices data loggers were used (Em50with VP-3, 5TM; Decagon Devices Inc, Pullman, WA). Measurements were recorded every 15 min and hourly or daily means were calculated from these data. Under the high tunnels, each monitoring station was located ≈2.4 m from the closest side wall and 10.2 m from the closest end wall to capture average high tunnel conditions. Air temperature and relative humidity sensors were housed within protective plastic radiation shields 1 m above the soil surface. Soil temperature was measured belowground at a depth of 10 cm. Placements of monitoring stations in the field were set up to mimic the locations under the high tunnels.
Monitoring stations under the high tunnels were covered with intermediate weight rowcovers (i.e., 40.7 g·m−2) (‘Gro-Guard #40’; Atmore Industries) along with the crop plants on nights predicted to be ≤0 °C. Row covers were not used in the field where there was an oat cover crop growing. GDD were calculated using the average daily temperature generated by monitoring stations minus the base temperature of 7.2 °C (Dufault, 1997).
The main factors of interest in this study were a comparison between two planting dates and either four broccoli cultivars or three cauliflower cultivars. Therefore, the continuous response variables included in this dataset were marketable yield and average days to harvest. Individual marketable head fresh weight was obtained by dividing the total weight of marketable heads by the total number of marketable heads per plot. These variables were about normally distributed so the statistical analysis was carried out using a mixed effects analysis of variance model (SAS Institute, Cary, NC); the data did not require any transformation and block was considered a random effect. Tukey’s mean separation method with 95% confidence level was used to determine if there were significant differences between planting dates or cultivar type for each crop. Each year was analyzed separately to account for different weather patterns.
The response variables related to non-marketable yield (i.e., culls) were analyzed differently because they comprised small positive integers that were not continuous. A logistic regression model was used to predict the proportion of the total harvested heads that were non-marketable using planting date or cultivar type as explanatory variables for each crop type (SAS Institute). Block was considered a random effect. Each year was analyzed separately to account for different weather patterns.
Statistical analysis was not conducted on the microenvironmental data; however, the average daily and monthly values are presented (i.e., air temperature, soil temperature, relative humidity, and GDD). This provides a useful comparison between the high tunnel and field microenvironments across the growing season and between years at our research site as well as to compare with other regions conducting high tunnel research.
The marketable yield ranged from ≈13,100 to 15,800 kg·ha−1 in 2014–15 and 11,800 to 13,400 kg·ha−1 in 2015–16 (Table 2). In both growing seasons, the average marketable yield was unaffected by planting date. Differences among cultivars were evident in 2014–15 when ‘Belstar’ had a greater average weight per head compared with ‘Marathon’ but was not different from ‘Fiesta’ or ‘Imperial’ (Table 2). In addition to head weight, the diameter of each broccoli head was measured. Broccoli heads were informally categorized as small (12.7–15.1 cm), medium (15.2–17.8 cm), or large (17.9–20.3 cm) diameter. In 2014–15, ≈65% of the broccoli heads for both planting dates were considered medium-sized or larger (Table 2). In 2015–16, the same was true for the first planting date but only 55% were considered medium-sized or larger for the second planting date (Table 2). Both planting dates and all broccoli cultivars had high rates (87% to 98%) of marketability (Table 2). During the 2014–15 season, rodent damage accounted for the greatest loss, until snap traps were deployed, compared with over-maturity in 2015–16 (Table 2).
Mean monthly air temperatures (°C) for high tunnels compared with the open field, 2014–16.
The effect of planting date on broccoli days to harvest after transplanting was inconsistent across the two seasons. The seed catalog estimates for days to harvest were 65, 68, 71, and 75 d for ‘Belstar’, ‘Marathon’, ‘Imperial’, and ‘Fiesta’, respectively. In 2014–15, an additional 21–45 d was required, and in 2015–16, an additional 8–21 d was required compared with the seed catalog estimates depending on the planting date and cultivar. During the 2014–15 season, the first planting date was an average of 10 d quicker to harvest than the second planting date (Table 2). In addition, ‘Imperial’ and ‘Marathon’ were ≈5 d earlier to harvest compared with ‘Belstar’ and ‘Fiesta’. In 2015–16, both planting dates were earlier to mature than the previous season, and there were no significant differences among the average days to harvest (≈84–85 d) (Table 2). Across both years, the only consistent significant interaction was between the first planting date and cultivar type which indicated that ‘Imperial’ matured ≈1 week earlier than ‘Belstar’ or ‘Fiesta’ broccoli (P < 0.03).
The marketable yield ranged widely from ≈8600 to 26,000 kg·ha−1 in 2014–15 and 9300 to 23,300 kg·ha−1 in 2015–16 (Table 3). During both growing seasons, the average marketable yield was unaffected by planting date but cultivar type had a significant effect on crop yields. ‘Denali’ had a greater average marketable yield compared with ‘Snowball Y’ across both growing seasons, and ‘Denali’ was also greater than ‘Amazing’ in 2014–15 (Table 3).
Monthly growing degree days under high tunnels by season.
In addition to weight, the diameter of each cauliflower head was measured. Most were informally categorized as large (15.2–17.8 cm) or x-large (17.9–20.3 cm). The average cauliflower head diameter did not appear to be affected by planting date or cultivar type (Table 3). Across both seasons, ‘Denali’ and ‘Amazing’ had high rates of marketable heads (90% to 99%) but only ≈50% to 60% of ‘Snowball Y’ were considered marketable (Table 3). During both seasons, bracting and riciness which were both categorized as “overmature” accounted for the greatest losses followed by the “other” category which included buttoning and the failure to form a head (Table 3).
Cultivar affected the number of days to harvest after transplanting in the following ascending order: ‘Amazing’ (87–99 d), ‘Denali’ (93–107 d), and ‘Snowball Y’ (113–126 d) (P < 0.0001). All cultivars required additional days to harvest compared with seed catalog estimates which were 68, 73, and 70 d for ‘Amazing’, ‘Denali’, and ‘Snowball Y’, respectively. During 2014–15, an additional 31–43 d to harvest was required, and in 2015–16, an additional 19–56 d to harvest was required compared with seed catalog estimates. The only significant interaction between planting date and cultivar type was in 2015–16, when the first planting date of ‘Snowball Y’ cauliflower was 2 weeks slower to mature than the second planting date (P < 0.0001).
In general, the 2014–15 season was cooler than the 2015–16 season (Table 4). Row covers were used as an added layer of cold protection on nights predicted to be ≤0 °C. Therefore, rowcovers were used to cover the crops ≈50 times in the 2014–15 season compared with ≈30 times in the 2015–16 season due to frost predictions. The difference in temperature between the two seasons was also reflected in the estimated GDD. The GDD under the high tunnels were ≈340 units lower for the first compared with the second growing season (Table 5). The accumulation of GDD was the lowest during the months of January and February both years (Table 5).
Comparison of mean broccoli yield and days to harvest under a tunnel system, 2014–16.
Comparison of marketable cauliflower yield and days to harvest under high tunnels, 2014–16.
The average daily air temperature across the growing season under the high tunnels was ≈1 to 4 °C warmer than the field at the crop canopy height (Table 4). In October at the beginning of the growing season, when temperatures were still warm and when the high tunnels were often fully vented, the average daily air temperature was ≈1 °C warmer under the high tunnels than the field (Table 4). The greatest heat gains were during the coldest months of January and February when the high tunnels were vented less frequently (Table 4). On the coldest days of each season, the high tunnels maintained a daily average temperature ≈7 to 8 °C warmer than the field (Table 4). The absolute minimum air temperatures (≈7:00 am) during the experiment were 3 to 4 °C warmer under the high tunnels compared with the field.
Soil temperatures demonstrated similar trends with air temperatures. The average daily soil temperature under the high tunnels ranged from ≈3 to 7 °C greater than the field across both growing seasons. Figure 1 shows data from the 2014–15 season (i.e., colder season). The average daily soil temperature rarely went below 10 °C under the high tunnels, and neither the high tunnel nor the field system soil dropped below 3 °C during the growing season (Fig. 1). The relative humidity of both the high tunnel and field systems was about the same when the high tunnels were fully vented during the beginning of the season. Figure 2 shows data from the 2015–16 season (i.e., the wetter season). Later in the winter season, when high tunnels were closed up more frequently for rain events or cold, the daily average relative humidity in the high tunnels was greater than the open field (Fig. 2). For most of the season, daily average relative humidity levels under the high tunnels ranged from 70% to 100%.
Differences among planting dates and cultivar type did not appear to have a major or consistent influence on the average marketable yield of fall/winter broccoli grown under our high tunnel system, although the cultivar ‘Imperial’ was slightly quicker to mature (≈1 week) compared with ‘Belstar’ and ‘Fiesta’. In addition, all planting dates and cultivars demonstrated a high percentage of marketability, and our yields were equal or greater than another organic open field broccoli study conducted at the same location in Georgia (Boyhan et al., 2016). There were no indications of damage to the either broccoli or cauliflower heads grown under the high tunnels because of cold temperatures during the experimental timeframe, although some leaf tissue showed signs of frost damage later in the season.
Planting dates ranging from mid-September to late-October seemed feasible in terms of achieving a high quality crop that could be harvested from December through January (i.e., 85–100 d after transplanting), although this depends on weather conditions and high tunnel and crop management protocols. The diversity of high tunnel structures and management strategies makes comparing study results challenging. Such comparisons would be very valuable to provide guidance to regional high tunnel growers.
The average broccoli harvest dates during the 2014–15 season were in the middle of January and the beginning of February. Because we thought there would be financial benefits to both, an earlier crop maturity and greater overlap with winter holiday markets, we advanced our planting dates by 2 weeks in the 2015–16. As a result, in the second season, the average broccoli harvest dates coincided with the middle and end of December; however, a confounding factor was that 2015–16 was also a warmer season. The average days to harvest was longer than seed catalog estimates (≈10–40 d longer) depending on the year, planting date, and cultivar which is something to consider for fall/winter crop planning.
The average broccoli yield was lower in 2015–16, and this appeared to correspond with an increasing incidence of loose or flowering buds (i.e., indicator of heat stress) that affected our harvest decisions. Broccoli heads showing early signs of loose or flowering buds were harvested twice a week and categorized as marketable or non-marketable depending on the severity of physiological disorders. Harvesting more frequently likely would have reduced the number of heads that were deemed non-marketable. The impact of heat units and fluctuating temperatures on maturity dates, cultivar selection, and physiologic disorders for broccoli under high tunnels is a topic that would benefit from further exploration. Also, we chose to maximize head size (i.e., dinner-plate size) before harvesting, but many growers choose to harvest smaller heads and then return to cut subsequent side shoots (Sanchez et al., 2016); this decision impacted our days to harvest and total yield estimates.
Broccoli was about 2 weeks slower to mature in 2014–15 compared with 2015–16. This delay is likely attributable to colder growing temperatures and lower accumulation of GDD during the first growing season compared with the second season. It is impossible to evaluate whether temperature or light was the more limiting factor for crop growth in this study. The slowest GDD gains were in January and February which are the coldest and most light limited months in the region. Determining the minimum GDD and DLI for a variety of horticultural crops would be beneficial for high tunnel growers.
According to Maynard and Hochmuth (2007), optimum mean daily temperature for B. oleracea plant growth ranges between 15 and 18 °C. Temperature ranges during the month of October for both years during our experiment were within the optimal range but then dropped below it in November and for the remainder of the season. It is possible that increasing the temperature set point for opening our high tunnel sidewalls (>15.6 ± 1 °C) would have led to more favorable average daily temperatures during the month of November and December across both years.
Most broccoli cultivars also appear to have a quantitative cold requirement or vernalization period to produce flowers (i.e., buds) below 24 °C which is warmer than many other brassica crops (Fontes et al., 1967; Wurr et al., 1995). We were below these broccoli vernalization thresholds from November through February, but it remains a challenge for regional high tunnel growers to manage daily temperature fluctuations as the crop progresses from vegetative to generative plant growth. An additional complication is managing/optimizing high tunnel temperatures when multiple different crops are grown under a single high tunnel.
Cauliflower yield, quality, and days to harvest were affected by cultivar type but not planting date. ‘Denali’ and ‘Amazing’ had high productivity and quality in our high tunnel systems and appear to be suitable cultivars for fall/winter production, but ‘Snowball Y’ did not perform well. ‘Denali’ and ‘Amazing’ produced heads with similar diameters and percent marketability. ‘Denali’ heads weighed more than ‘Amazing’ which may provide an advantage in different markets (i.e., weight vs. piece).
In both seasons, most of the crop was harvested during the month of January ≈100–110 d posttransplanting. The actual days to harvest for the ‘Amazing’ and ‘Denali’ cauliflower was 20–40 d longer than the seed catalog estimates. The cultivar ‘Amazing’ was slightly earlier (≈1 week) to mature compared with ‘Denali’, which could result in slightly more efficient use of high tunnel space (i.e., less time for a marketable product). These planting dates did not overlap with winter holiday market either year. The extended time may be linked to suboptimal temperatures for plant growth or curd formation and decreased light during the winter months.
Our monthly average air temperatures under the high tunnels were in the optimal vegetative growth range for cauliflower (16 to 18 °C) (Smith and Doubrava, 2003) from planting date through the month of October. Similar to broccoli, although lower, many cauliflower varieties require a vernalization period with temperatures between 10 and 16 °C for curd initiation (Wurr et al.,1993; Grevsen and Olesen, 1994). Our high tunnel systems had air temperatures that fluctuated above and below these vernalization temperatures from December through February. The ‘Snowball Y’ cultivar appeared much more susceptible to the high tunnel system temperatures than ‘Amazing’ and ‘Denali’ which was expressed by increased rates of bracting, riciness (i.e., non-marketable “overmature”), and buttoning and the failure to form heads (i.e., non-marketable “other”). Most of these physiological disorders are attributed to less than optimal temperature regimes (Wurr and Fellows, 1998). Therefore, cultivar selection seems critically important for offseason high tunnel cauliflower production that may be subject to warmer temperatures than the field during critical development phases or more extreme temperature fluctuations.
There were a number of structural components to our high tunnel system that influenced the microenvironment such as the inflated double-poly roof, polycarbonate end walls, and woven fabric side curtains. In addition, cultural practices employed including using black polypropylene landscape fabric mulch, opening and closing side curtains when ambient temperatures were >15.6 ± 1 °C, and using intermediate weight rowcovers when temperatures were predicted to be ≤0 °C likely influenced daily temperatures especially heat gains on cold days and evenings. All of these features were part of our high tunnel system and we did not evaluate their individual effects. Other researchers, for example, have found that heavy weight rowcovers (51 g·m−2) alone can provide up to 3 °C on cold evenings (Takeda et al., 2008). Conversely, tall side walls (1.8 m openings) and end walls (4.9 m openings) helped ventilate on warm days and keep air temperatures and relative humidity levels near the crop canopy similar to the open field situation.
Overall all broccoli cultivars trialed (i.e., ‘Imperial’, ‘Marathon’, ‘Belstar’, and ‘Fiesta’) achieved high levels of marketability with frequent harvesting and were faster to reach maturity than cauliflower. Differences of cauliflower yield were more pronounced and demonstrated varying degrees of sensitivity to the high tunnel environment (i.e., ‘Denali’ and ‘Amazing’ > ‘Snowball Y’). Although high tunnel temperatures over the fall/winter did appear conducive to many cool-season crops, light levels and sensitivity to fluctuating temperatures must be considered along with crop type, cultivar choice, and planting dates. As anticipated, differences in yearly weather patterns influenced both crop yields and days to harvest. Further investigations into the trade-off between slower crop growth during winter (i.e., January and February) for brassica crops alongside market demand (i.e., price premiums, market attraction/retention, etc.) would help determine if these crops are profitable choices for regional growers.
Boyhan, G.E., Gaskin, J.W., Little, E.L., Fonsah, E.G. & Stone, S.P. 2016 Evaluation of cool-season vegetable rotations in organic production HortTechnology 26 637 646
Carey, E.E., Lamont, W.J. Jr, Nennich, T.T., Orzolek, M.D. & Williams, K.A. 2009 Horticultural crop production in high tunnels in the United States: A snapshot HortTechnology 19 37 43
Fitzgerald, C.B. & Hutton, M. 2012 Production practices and challenges with high tunnel systems in Maine J. NACAA 5 2 7 Nov. 2017. <https://www.nacaa.com/journal/index.php?jid=170>
Fontes, M.R., Ozbun, J.L. & Sadik, S. 1967 Influence of temperature on initiation of floral primordial in green sprouting broccoli J. Amer. Soc. Hort. Sci. 91 315 320
Gu, S., Guan, W. & Beck, J. 2017 Strawberry cultivar evaluation under high-tunnel and organic management in North Carolina HortTechnology 27 84 92
Hochmuth, R.C. & Toro, D.E. 2014 Characterization of the Florida fresh fruit and vegetable industry using hydroponic systems or protected agriculture structures. Univ. of FL-IFAS Extension Pub. #HS1240
Jayalath, T.C. 2016 The evaluation of high tunnel systems for spring organic lettuce production in Georgia. Univ. of Georgia, Athens, Master’s Thesis
Korcyznski, P., Logan, J. & Faust, J.E. 2002 Mapping monthly distribution of daily light integrals across the contiguous United States HortTechnology 12 12 16
Maynard, D.N. & Hochmuth, G.J. 2007 Knott’s handbook for vegetable growers. 5th ed. John Wiley and Sons, Inc., Hoboken, NJ
National Centers for Environmental Information (NCEI) 1982 Asheville, Climate of Georgia. 5 Apr. 2017. <https://www.ncdc.noaa.gov/climatenormals/clim60/states/Clim_GA_01.pdf>
NRCS-USDA 1968 Soil survey of Clarke and Oconee Counties of Georgia. 1 June 2014. <http://www.nrcs.usda.gov/Internet/FSE_MANUSCRIPTS/georgia/clarke_oconeeGA1968/CO.pdf>
O’Connell, S., Rivard, C.L., Peet, M.M., Harlow, C. & Louws, F. 2012 High tunnel and field production of organic heirloom tomatoes: Yield, fruit quality, disease and microclimate HortScience 47 1283 1290
Ogden, A.B. & van Iersel, M.W. 2009 Southern highbush blueberry production in high tunnels: Temperatures, development, yield, and fruit quality during the establishment years HortScience 44 1850 1856
Sanchez, E., Butzler, T., Stivers, L., Pollock, R., Elkner, T., Bogash, S. & Lamont, W. 2016 Performance of broccoli cultivars in spring and fall evaluations in Pennsylvania HortTechnology 26 869 876
Salame-Donoso, T.P., Santos, B.M., Chandler, C.K. & Sardent, S.A. 2010 Effect of high tunnels on the growth, yields, and soluble solids of strawberry cultivars in Florida Intl. J. Fruit Sci. 10 3 249 263
Smith, P. & Doubrava, N. 2003 Cauliflower #HGIC 1326 Clemson University Coop. Expt. 27 June 2017. <http://www.clemson.edu/extension/hgic/plants/pdf/hgic1326.pdf>
Takeda, F., Demchak, K., Warmund, M.R., Handley, D.T., Grube, R. & Feldhake, C. 2008 Rowcovers improve winter survival and production of western trailing ‘Siskiyou’ blackberry in the eastern United States HortTechnology 18 575 582
USDA 2012a USDA plant hardiness zone map. 24 Aug. 2015. <http://planthardiness.ars.usda.gov/PHZMWeb/>
USDA 2012b More communities warm up to winter markets. Release No. 0352.12. 14 Sept. 2016. <https://www.usda.gov/media/press-releases/2012/12/06/more-communities-warm-winter-markets>
US Government Publishing Office 1990 7 U.S. Code §6507–State organic certification program. 22 Aug. 2015. <http://www.gpo.gov/fdsys/granule/USCODE-2011-title7/USCODE-2011-title7-chap94-sec6507>
USNO 2015 (U.S. Naval Observatory). 16 May 2017. <http://aa.usno.navy.mil/data/docs/Dur_OneYear.php>
Wallace, R.W., Wszelaki, A.L., Miles, C.A., Cowan, J.S., Martin, J., Roozen, J., Gundersen, B. & Iglis, D.A. 2012 Lettuce yield and quality when grown in high tunnel and open-field production systems under three diverse climates HortTechnology 22 659 668
Wurr, D.C.E., Fellows, J.R., Phelps, K. & Reader, R.J. 1993 Vernalization in summer/autumn cauliflower (Brassica oleracea var. botrytis L.) J. Expt. Bot. 44 9 1507 1514
Wurr, D.C.E., Fellows, J.R., Phelps, K. & Reader, R.J. 1995 Vernalization in calabrese (Brassica oleracea var. italica)–a model for apex development J. Expt. Bot. 46 10 1487 1496
Wurr, D.C.E. & Fellows, J.R. 1998 Leaf production and curd initiation of winter cauliflower in response to temperature J. Hort. Sci. Biotechnol. 73 5 691 697