Chlorine from calcium hypochlorite, sodium hypochlorite, or Cl gas sources has complex chemistry in irrigation water. Once added to water, Cl is converted to hypochlorite (OCl–) and hypochlorous acid (HOCl), which along with dissolved Cl gas are collectively termed free Cl. The balance between hypochlorous acid and hypochlorite is pH-dependent, whereby hypochlorous acid predominates at solution pH below 7.5 or hypochlorite ions above pH 7.5 (Morris, 1966). Water pH also influences the sanitizing strength of a Cl solution, because HOCl is estimated at up to 80× more effective as a biocide than OCl– (White, 1992). The effect of pH on control of waterborne pathogens in a Cl solution was illustrated by Lang et al. (2008), whereby control of Pythium aphanidermatum and P. dissotocum zoospores was achieved at either 2.0 mg·L−1 Cl at pH 8.1 or 0.5 mg·L−1 Cl at a pH of 6.3.
There is extensive research on effects of free Cl on waterborne plant pathogens. Control of Pythium and Phytophthora zoospores has been reported with 2 mg·L−1 of free Cl (Cayanan et al., 2009; Hong and Richardson, 2004; Hong et al., 2003; Lang et al., 2008). Chlorine oxidizes and chlorinates living tissue and organic compounds, resulting in damage to membranes, enzymes, and nucleic acids of microorganisms (Stewart and Olson, 1996). Increasing concentration of Cl, lowering solution pH, increasing ORP, and increasing contact time are factors that improve pathogen control (Lang et al., 2008).
Oxidative strength of a Cl solution can be measured in millivolts (mV) using an ORP meter. A positive correlation was found between ORP and control of coliform bacteria by chlorination of wastewater (Yu et al., 2008). Coliforms and pathogenic bacteria were rapidly controlled in post-harvest wash water if ORP was maintained between 650 and 700 mV (Suslow, 2004). Lang et al. (2008) found that Pythium aphanidermatum and P. dissotocum zoospores were killed within 0.25 to 0.5 min when ORP was above 780 mV in chlorinated water.
In municipal water treatment facilities, a dose of one part of inorganic N to every three parts of free Cl reportedly results in 99% conversion of free Cl to chloramines after 0.2 s at pH 7 or 147 s at pH 4 (White, 1992). In horticulture irrigation, water-soluble fertilizer containing ammonium, nitrate, and/or urea N is often supplied in irrigation between 100 and 200 mg·L−1 total N and then treated with free Cl concentrations between 1 and 2 mg·L−1 Cl. With such a high N to Cl ratio, the majority of free Cl would therefore be expected to rapidly convert to chlorinated N forms. Chlorine also reacts with urea, although the chain of reactions is more complex and slow-acting than chlorination of ammonia (Blatchley and Cheng, 2010).
Chloramines are considered weaker sanitizers than free Cl from hypochlorous acid (White, 1992) because of the longer contact time that chloramines require to control human pathogens compared with an equal concentration of free Cl. Control of 99% of Escherichia coli with hypochlorous acid at 1 mg·L−1 Cl required a 1-min contact time, whereas with combined Cl forms including NH2Cl and NHCl2 at 1 mg·L−1 Cl required more than 100 min (Akin et al., 1982). However, the greater stability of chloramines in the presence of organic compounds compared with hypochlorous acid may increase penetration of chloramines into biofilm, resulting is greater inactivation of biofilm bacteria (LeChevallier et al., 1988). The American Water Works Association (AWWA, 1991) provided guidelines for residual concentration of between 0.5 to 1 mg·L−1 chloramine for disinfection of groundwater (White, 1992) such as from wells or irrigation catchment areas. Based on experience with control of human pathogens in water supply, irrigation of edible crops with complexed Cl is likely to require longer contact times and/or higher total Cl application concentrations compared with free Cl for control of human pathogens. However, data are not available for plant pathogens.
There are limited research data on the residual level of free or total Cl in the presence of nutrient solutions despite the common practice of dual injection of Cl and water-soluble fertilizer and the potential impact on pathogen control. The research objective of this study was to determine the free and total Cl and ORP responses over time when nutrient solutions were blended with sodium hypochlorite.
American Public Health Association 1995 Standard methods for the evaluation of water and wastewater. 18th Ed. Amer. Public Health Assn., Denver, CO
American Water Works Association 1991 Guidance manual for compliance with the filtration and disinfection requirements for public works systems using surface water sources. U.S. Environmental Protection Agency, Office of Groundwater and Drinking Water, Washington, DC
Cayanan, D.F., Zhang, P., Liu, W., Dixon, M. & Zheng, Y. 2009 Efficacy of chlorine in controlling five common plant pathogens HortScience 44 157 163
Copes, W.E., Chastaganer, G.A. & Hummel, R.L. 2004 Activity of chlorine dioxide in a solution of ions and pH against Thielaviopsis basicola and Fusarium oxysporum Plant Dis. 88 188 194
Date, S., Terabayashi, S., Kobayashi, Y. & Fujime, Y. 2004 Effects of chloramines concentration in nutrient solution and exposure time on plant growth in hydroponically cultured lettuce Sci. Hort. 103 257 266
Degreìmont, S.A. 1979 Water treatment handbook. Halsted Press, New York, NY
Environmental Protection Agency 1999 Guidance manual for alternative disinfectants and oxidants. Environ. Protection Agency, Office of Groundwater and Drinking Water, Washington, DC. 12 Nov. 2012. <http://water.epa.gov/lawsregs/rulesregs/sdwa/mdbp/upload/2001_01_12_mdbp_alter_chapt_6.pdf>
Hong, C.X. & Richardson, P.A. 2004 Efficacy of chlorine on Pythium pathogens in irrigation water. Proc. S. Nursery Assn. Rsch. Conf. 49:265–267
Hong, C.X., Richardson, P.A., Kong, P. & Bush, E.A. 2003 Efficacy of chlorine on multiple species of Phytophthora in recycled nursery irrigation water Plant Dis. 87 1183 1189
Lang, J. M., Rebits, B., Newman, S.E. & Tisserat, N. 2008 Monitoring mortality of Pythium zoospores in chlorinated water using oxidation reduction potential. Plant Health Progress. Bul. 0922
Stewart, M.H. & Olson, B.H. 1996 Bacterial resistance to potable water disinfectants, modeling disease transmission and its prevention by detection. Cambridge U. Press, Cambridge, UK. p. 140–142
Suslow, T.V. 2004 Oxidation-reduction potential for water disinfection monitoring, control, and documentation. U. of California, Div. Ag. Nat. Res. Bul. 8149
White, G.C. 1992 Handbook of chlorination and alternative disinfectants. 3rd Ed. Van Nostrand Reinhold Co., New York, NY
Yu, R.F., Chen, H.W., Cheng, W.P. & Shen, Y.C. 2008 Dynamic control of disinfection for wastewater reuse applying ORP/pH monitoring and artificial networks Resour. Conserv. Recycling 52 1015 1021